Fisher and Paykel DishDrawer DD602 Service Manual

Service Manual, Parts List Manual and Installation Manual for Fisher and Paykel DishDrawer DD602;
This manual is in the PDF format and have detailed Diagrams, pictures and full procedures to diagnose and repair your Paykel DishDrawer DD602.
– Models covered by Service Manual: DD602, DD602I, DS602, DS6021;
– Models covered by Parts List Manual: DD601, DD601I, DD601V2, DD601V2I, DD602, DD602I, DS601, DS601I, DS601V2, DS601V2I, DS602, DS602I;
– Models covered by Installation Manual: DD602, DD602I;

CONTENTS:
1.0 SERVICE REQUIREMENTS
1.1 HEALTH & SAFETY
1.1.1 Electrical Safety
1.1.2 Electrostatic Discharge
1.1.3 Good Working Practices
1.1.4 Isolate Water Supply 5
1.1.5 Water Leak Check
1.1.6 Insulation Test 6
1.1.7 Solvent and Excessive Heat Damage
1.1.8 Sheet Metal Edges 6
1.1.9 Diagnostics
1.2 SPECIALISED TOOLS
1.2.1 Static Strap
1.2.2 Down Load Pen Connection: P/N 425930C
1.2.3 Down Load Serial Connection: P/N 425376C
1.2.4 Perspex Test Lid: P/N 525826
1.2.5 Air Gauge and Plumbing. P/N 525819

2.0 DIMENSIONS & SPECIFICATIONS

3.0 TECHNICAL OVERVIEW
3.1 ELECTRONICS
3.2 MOTOR
3.3 CABINET
3.3.1 Chassis
3.3.2 Drawer Fronts
3.4 FILLING
3.4.1 Cold Inlet
3.4.2 Mixing the Detergent
3.4.3 Amount of Water
3.5 DISPENSING DETERGENT
3.6 LID SEAL
3.6.1 When Activated
3.6.2 What is the Lid Seal
3.6.3 During Wash
3.7 WASH CYCLE
3.7.1 Tub
3.7.2 Rotor
3.7.3 Spray arm
3.8 HEATING
3.8.1 The Element
3.8.2 Heating the Water
3.8.3 Maintaining the Temperature
3.8.4 Overheating Control
3.9 FILTER PLATE
3.9.1 The Filter System
3.9.2 Removing and Cleaning the Filter Plate
3.10 DRAIN CYCLE
3.11 DRYING CYCLE
3.12 DEFLATING
3.12.1 Lid Seal
3.12.2 When the Lid Seal Deflates
3.13 LOCKRING NUT
3.14 WIRING COVER

4.0 DIAGNOSTICS
4.1 SETUP & DIAGNOSTICS
4.2 FAULT MODES
4.3 DIAGNOSTIC MODES
4.3.1 Temperature Display Mode
4.3.2 Rinse Aid / Tub-Open Beep Water Pressure Setup Mode
4.3.3 Rinse Aid Setup
4.3.4 Tub-Open Beep Setup
4.3.5. Water Pressure Set Up
4.3.6 Dishwasher Diagnostics
4.3.7 Display / Download Mode
4.3.8 Optical LED Download / Fault Display
4.3.9 Clearing Fault Logs
4.3.10 Show Off Mode
4.3.11 Hardware Output Diagnostic Test Mode
4.3.12 Continuous Cycle Life Test Mode
4.4 DIAGNOSTICS QUICK REFERENCE FLOW CHART
4.4 DIAGNOSTICS QUICK REFERENCE FLOW CHART CONT’D
4.5 FAULT CODES

5.0 WIRING DIAGRAM

6.0 SERVICE PROCEDURES
6.1. DRAWER FRONT REMOVAL
6.2. HANDLE AND LCD DISPLAY REMOVAL
6.3 DRYING FAN REMOVAL
6.4 DETERGENT DISPENSER
6.5 ELECTRONIC CONTROLLER
6.6 TOP KICK STRIP REMOVAL
6.7 LOWER KICK STRIP REMOVAL
6.8 WIRING COVER REMOVAL
6.9 FILTER PLATE REMOVAL
6.10 ROTOR ASSEMBLY REMOVAL
6.11 TUB REMOVAL
6.12 LOCKING RING, ELEMENT PLATE AND MOTOR ASSEMBLY REMOVAL
6.13 LID ASSEMBLY REMOVAL
6.14 LID SEAL REPLACEMENT
6.15 SLIDE RUNNER REPLACEMENT
6.16 FRONT TRIM REPLACEMENT
6.17 SOUND GASKET REPLACEMENT
6.18 LINK ASSEMBLY REMOVAL
6.19 AIR PUMP REMOVAL
6.20 EXHAUST VALVE REMOVAL
6.21 WATER VALVE REMOVAL
6.22 FLOOD SWITCH REMOVAL
6.23 EMI FILTER REMOVAL
6.24 TUB MICROSWITCH REMOVAL

Language: English